内容发布更新时间 : 2024/9/19 17:57:19星期一 下面是文章的全部内容请认真阅读。

l29, the company responsible for a variety of procedures for reimbursement document, invoice review, approval of work; 30, regularly convened general meeting of shareholders, preparation work for the meeting; 31, the company responsible for payroll management jobs, including around salary survey, employee salary, salary accounting methods developed, payroll accounting, payment of wages, bonuses; 32, the company responsible for delivery of financial procedures; 33, according to the company's strategic development plan, the preparation and management of funds to meet day-to-day operating funding requirements to ensure the company's safety, liquidity and profitability of the funds; 34, responsible for the environmental protection building materials Corporation issued by the Corporation Annual, monthly economic indicators in the assessment of the economic responsibility system of proposed amendments; 35, the company responsible for all types of contracts and tracking, implementation, implementation of the agreement, abnormality was detected in time to take appropriate measures and feedback to the leadership; 36, regularinspection, analysis, budget implementation of the business and financial performance, and to propose measures to increase revenue and reduce expenditure; 37, responsible for organizing the company's contracting business tenders; 38, responsible for preparing the annual budget and final accounts, distribution of profits, loss compensation plan; 39, responsible for the violations of financial discipline, or damage the company's interests (corruption and bribery) review of the Act; 40,福建爱婴日用品有限公司作业指导书 燃油蒸汽锅炉安全操作规程 开始实施日期 2013年11月15日 文件编号 修改状态 页 次 WI-01-0014A 0/A 第1页 共1页 安全 操作流程 1、电控操作 （1）锅炉房配备所需安全电源，以便保护锅炉房用电设备，同时检查水路、油路的安装是否正常； （2）锅炉控制柜电源接入前，联接好水泵、燃烧器、电极筒等，电源接入控制柜，逐个检查水泵运转、燃烧器运转是否正常，正常后检查自动给水控制、报警等是否正常，试运转正常后进入下一步工作。 2、工作试验： （1）煮炉 a.煮炉所用药物配制成20%的均匀溶液，不得将药品直接加入锅炉； b.锅炉燃烧煮炉，当压力升至工作压力时，维持此压力24小时，然后停止燃烧，当水温低至70℃时，开启排污阀将炉水全部放空，待锅炉自然冷却后开启入孔，手孔盖，用清水冲洗锅筒内部，并进行检查，如发现仍有油垢，表面仍有锈斑等，应按上述办法再行煮炉，直至锅筒内无油垢，金属表面无锈斑，管道与阀门清洁无堵塞，逐鹿才算合格。 （2）给水要求 用户应按总图中锅炉水质指标的规定，根据本地区水质情况和生产要求，选用水处理设备，没有采取可靠的给水处理措施的锅炉，不得投入运行。锅炉运行期间给水和炉水水质应符合总图中所定水质指标。 （3）升温及安全阀调整 将经过水质处理的软水送入锅炉，开启排气阀，以利锅筒内空气排出，当水位达到正常水位的下限时，锅炉即可点火。当压力升至工作压力时，转入间断式燃烧状态后，0.1Mpa以下的锅炉采用静重式安全阀不需调整，弹簧式安全阀的始启压力为工作压力＋0.03Mpa。 注意事 项 1、使用本设备必须遵循本说明书所述程序； 2、此种锅炉自控水平相当高，正常运行时，锅炉水位上下波动范围很小； 3、为防止水位表堵塞，水位表玻璃板模糊不清，水位表每班至少冲洗一次，如果锅炉水 位自控报警器失灵，应立即停炉进行修理或更换； 4、锅炉工作压力最高不允许超过额定工作压力； 5、安全阀应定期作排气试验，一般2~4周作一次，以校准安全阀的作用； 6、排污必须是在锅炉处于高水位低负荷时进行，排污时一定要注意水位变化。 编制 技术部 审核 赖嘉雄 批准 赵荣茂 l29, the company responsible for a variety of procedures for reimbursement document, invoice review, approval of work; 30, regularly convened general meeting of shareholders, preparation work for the meeting; 31, the company responsible for payroll management jobs, including around salary survey, employee salary, salary accounting methods developed, payroll accounting, payment of wages, bonuses; 32, the company responsible for delivery of financial procedures; 33, according to the company's strategic development plan, the preparation and management of funds to meet day-to-day operating funding requirements to ensure the company's safety, liquidity and profitability of the funds; 34, responsible for the environmental protection building materials Corporation issued by the Corporation Annual, monthly economic indicators in the assessment of the economic responsibility system of proposed amendments; 35, the company responsible for all types of contracts and tracking, implementation, implementation of the agreement, abnormality was detected in time to take appropriate measures and feedback to the leadership; 36, regularinspection, analysis, budget implementation of the business and financial performance, and to propose measures to increase revenue and reduce expenditure; 37, responsible for organizing the company's contracting business tenders; 38, responsible for preparing the annual budget and final accounts, distribution of profits, loss compensation plan; 39, responsible for the violations of financial discipline, or damage the company's interests (corruption and bribery) review of the Act; 40,福建爱婴日用品有限公司作业指导书 洗发水搅拌锅安全操作规程 开始实施日期 2013年11月15日 文件编号 修改状态 页 次 WI-01-015A 0/A 第1页 共1页 1、进料，按工艺配方加入水、油各种固体物料； 2、加热、搅拌，开始搅拌装置，搅拌转速视物料粘度选择，同时对锅体加热，锅体加热采用≤0.3Mpa的水蒸汽，加热前先排净夹套内冷凝水，关闭冷却水进口阀门，然后开启进蒸汽阀门，用户可通过温度表来检测加热情况，温度控制由手控来完成。用户在安全 操作流程 输气管路中须安装减压和限压装置。本设备配有压力显示及超压安全阀，保证设备运行安全； 3、冷却：一般采用自来水作为冷却水源（有条件的用户能采用冷冻水冷却效果更佳），关闭蒸汽管道阀门，开启进水阀门，掌握进水阀门的启闭程度来控制冷却水流量，达到控制冷却速度； 4、出料：物料搅拌均匀，制造结束后，打开放料阀出料，用户也可根据场地、设备及工艺情况采用泵出料； 5、清洗：出料结束后，若需要更换生产品种或空置时间超过24小时，则应对锅内进行清洗，可在锅内放入半锅清水，打开蒸汽阀门对锅体加热，启动搅拌装置对锅内进行清洗，然后再换半锅清水，按上述程序继续清洗。换水清洗次数视物料不同而定； 6、清洗结束后，放进锅内的水，最后，加热锅体，使锅内表面烘干。 注2﹑在没有冷却水源情况下不得启动快速搅拌装置，以免损坏； 意3﹑用户在设备使用过程中，必须定期送有关部门检定，调整各安全阀门的开启工作压力，事确保设备使用安全； 项 4﹑设备要有可靠的接地，接地电阻小于100。 1﹑定期检查，更换摆线针轮减速机内的润滑油脂； l29, the company responsible for a variety of procedures for reimbursement document, invoice review, approval of work; 30, regularly convened general meeting of shareholders, preparation work for the meeting; 31, the company responsibleor payroll management jobs, including around salary survey, employee salary, salary accounting methods developed, payroll accounting, payment of wages, bonuses; 32, the company responsible for delivery of financial procedures; 33, according to the company's strategic development plan, the preparation and management of funds to meet day-to-day operating funding requirements to ensure the company's safety, liquidity and profitability of the funds; 34, responsible for the environmental protection building materials Corporation issued by the Corporation Annual, monthly economic indicators in the assessment of the economic responsibility system of proposed amendments; 35, the company responsible for all types of contracts and tracking, implementation, implementation of the agreement, abnormality was detected in time to take appropriate measures and feedback to the leadership; 36, regularinspection, analysis, budget implementation of the business and financial performance, and to propose measures to increase revenue and reduce expenditure; 37, responsible for organizing the company's contracting business tenders; 38, responsible for preparing the annual budget and final accounts, distribution of profits, loss compensation plan; 39, responsible for the violations of financial discipline, or damage the company's interests (corruption and bribery) review of the Act; 40,编制 技术部 审核 赖嘉雄 批准 赵荣茂 福建爱婴日用品有限公司作业指导书 半自动活塞式灌装机安全操作规程 开始实施日期 2013年11月15日 文件编号 修改状态 页 次 WI-01-016A 0/A 第1页 共1页 1、打开气源开关，选择手动、自动选择开关，自动档时活塞往复运动，手动档时，轻踏脚踏阀，完成一次往复灌装； 2、检查设备，查看设备的过滤网是否完好； 3、将吸料管清洗消毒后放入盛有所需半成品的料桶中； 4、初始时料缸内有空气，先灌装几次，排清空气； 安5、根据产品的要求进行调整： a.灌装头：根据瓶口的大小，选择合适的灌装头； 全 b.瓶身高度：调节罐装头夹，选择适合的高度； 操c.灌装量：通过调节程控开关，调至所需的精度； 作d.灌装速度：前、后调速阀调整控制的空气流速，直接反映为气缸的速度、灌装速度、即灌装速度的控制装置。灌装调试完毕后，锁紧螺母锁灌，确定当前速度； 流6、开始灌装，在灌装过程中，如出现紧急情况，可按动急停开关； 程 7、灌装结束后，对设备进行清洗，在清洗之前，应把机器内的剩余产品清洗干净，然后依照设备清洗规程，将设备清洗消毒。 注1﹑在清洗之前必须检查压缩空气是否关闭，若无，关闭压缩空气 ； 意2﹑随时保持设备的周 围的卫生状况，撤去不必要的物品 。 事项